Samsung dryers are primarily silent; thus, any noise could be concerning, especially if it’s rumbling. So, is your Samsung dryer making loud rumbling noise, and you don’t know why?
Your Samsung dryer might be loudly rumbling because it’s off-balance, the blower wheel is defective, or perhaps it is due to a worn-out idler pulley or a loosely spinning drum.
One of those four reasons could be why your Samsung dryer is so deafening, and they are issues you can fix DIY. And, of course, the same problems could also trigger other dryer noises, which we’ll look at briefly in this post.
But first, I’ll explain the rumbling noise more. The goal is to enable you to not only stop your Samsung dryer from rumbling but also avoid such an annoying sound in the future. So, let’s jump in!
In a hurry? Below is a quick guide to the four issues causing a loud, rumbling dryer noise.
Samsung Dryer Making Loud Rumbling Noise – Quick Troubleshooting Guide
| – | Likely Cause | Quick Fix |
| 1. | An off-balance dryer | Steady your dryer (tighten loose feet and ensure the dryer rests on uniform and solid ground) |
| 2. | Defective blower wheel | Un-obstruct the blower wheel if it’s lint-obstructed, but replace it if it’s loose, damaged, or worn out. |
| 3. | Worn-out idler pulley | Replace a worn-out drum pulley. |
| 4. | Loosely spinning drum | Replace worn-out support rollers or roller axles. |
Why Is My Samsung Dryer Rumbling?
Typically, you expect a dryer to make some low-voice noise when it’s pretty new or unused for a long time. We call that the break-in period, which should be brief (about 5 minutes), and the noise should also be low volume.
Nevertheless, if your Samsung Dryer is rumbling quite loudly and the noise won’t stop or is too repetitive, it points to a fault. Here are some possible explanations for that:
1. The dryer might be off-balance
Your Samsung dryer will make some loud noise (sometimes a rumbling noise) when it’s out of balance. If so, it could be that its feet are loose or improperly leveled. And if that’s not the case, the dryer might be resting on an uneven or less solid surface.
Fix
Check the dryer’s feet level using the plumber’s spirit and adjust them if they are out of level. Tighten the feet with a wrench or spanner if they are loose, and ensure the dryer rests on even and solid ground.
2. The blower wheel could be defective
The blower wheel helps to blow air out of the heating chamber. It, however, struggles to do so when it’s lint-clogged, which could happen over time. When it does, it may make a loud rumbling noise.
But other than a lint obstruction, the blower wheel may wear down, loosen, or break over time, and when it does, it’ll struggle to execute its job. So, you have to inspect it for lint-obstruction and wear, looseness, and breakage.
Fix
Inspect the blower wheel to determine its condition, and you can find it on the motor shaft. Use your manual if you have difficulty locating it.
If the blower wheel is lint-obstructed, try cleaning the obstruction off. Remember, you should plug out the dryer and disassemble it to access the blower wheel.
If the blower is loose, damaged, or aged, replace it.
3. The idler pulley could be worn out
Another component you must inspect is the idler pulley. This dryer pulley gives the dryer belt the right amount of tension to stop it from slipping off and enable it to turn the drum efficiently.
If the idler pulley is worn out, it won’t add any tension to the belt, and the belt will, therefore, slip off and possibly make some rumbling noise. That’s not all. Your Samsung dryer may also have difficulty spinning.
Fix
Inspect the idler pulley for any wear or damage. If so, replace it.
4. The drum might be loosely spinning
Lastly, consider that the drum could be loose, and that’s why the dryer is making a rumbling sound. If that’s the case, a drum-support component has likely worn out, and it could be the support roller or roller axle.
Both the support rollers and roller axles support the drum as it rotates, and because of the repetitive spinning action of the drum, they wear down over time.
When they do, they cannot firmly support the drum as it turns, making it noisy. So, this could be why the drum makes an annoying rumbling noise while spinning.
Product Recommendation:
You probably want to replace the drum rollers or the idler pulley because it’s worn out. If so, get the Upgraded Sam-Sung Dryer Repair Kit (from Amazon), which features the drum rollers, idler pulley, and dryer belt. So, you can replace any of the three components and give your dryer a new internal look.
Remember to reset your Samsung dryer after a component replacement if there are any issues.
Other Samsung Loud Noises
Here are some other typical loud noises that a Samsung dryer can make besides a loud rumbling:
Samsung Dryer Making Loud Banging Noise
It’s not normal for a dryer to make a loud banging noise. It happens when something is amiss, and it could be anything from a laundry loading problem to a worn-out component.
A laundry loading problem could be an overload, a laundry imbalance, an oversized or bulky item such as a bathmat or jeans, or even large cloth buttons.
In the case of a worn-out component, consider the support bearings, drum rollers, and glides. If any of them is worn out, your Samsung dryer will make a noise, such as a loud rumbling.
Samsung Dryer Making Loud Vibrating Noise
A Samsung will vibrate for different reasons. First, it could be that the dryer is out of balance, which happens when it rests on an uneven or unsteady surface and when the feet are loose or wrongly leveled.
If the issue has nothing to do with an off-balance dryer, then it could be that something is rattling against the dryer’s outer wall. In that case, check for a loose power cord or dryer vent.
And if it’s none of those two issues, your Samsung dryer might vibrate loudly because of a laundry overload. In such a case, it could be that the drum is more than ¾ full, and so the clothes can’t spin properly.
Samsung Dryer Making Loud Grinding Noise
While several issues can make a dryer produce a grinding sound, the most typical explanations for Samsung models are laundry overload, ungreased hinges, and worn-out drum glides or bearings.
In that case, check if the drum is more than ¾ filled and reduce the laundry size. If the hinges are dry, lubricate them, and if it’s none of the two, check the drum glides and bearings for wearing out and replace them if that’s the case.
Samsung Dryer Making Loud Humming Noise
The humming sound is ordinarily not alarming, as you expect the dryer to make such a sound when the motor or drain pump runs. But again, this has to be brief and not too loud.
If your Samsung dryer is humming too loud, it could be an issue with the motor. The motor could be faulty but talk to a dryer pro if that’s not it. They know best! Or better, put your Samsung dryer in diagnostic mode.
Samsung Dryer Making Loud Rattling Noise
Lastly, a Samsung dryer may also make a loud rattling noise, which can be annoying. It does so when off-balance, resulting from loose or improperly leveled feet or an unsteady or uneven surface.
If the dryer is not off balance, the loud rattling could result from a laundry overload, and if that’s not it, then it’s highly likely that foreign objects like coins, screws, and keys obstruct the drum.
Don’t forget to check for a rattling object outside the dryer, such as a long hose or power cord.
People Also Ask
1. Why Is My Samsung Dryer Making Loud Noise?
Your Samsung Dryer is making a loud noise because something is amiss. Here are some issues to check out:
- Possible laundry overload or an unbalanced load
- An unsteady dryer – perhaps due to an uneven ground or loose feet
- Obstructed drum – perhaps by metallic objects like screws, keys, and coins
- Worn-out drum supportive components such as the support rollers, drum glides, drum rollers, and roller axles
- Motor, drive belt, or idler pulley malfunction
- An obstructed, damaged, loose, or worn-out blower wheel
- A rusty or ungreased door hinge
2. Why Is My Dryer Making a Loud Rumbling Noise?
Your dryer might be making a loud rumbling noise for different reasons. First, it could be that the dryer is off balance. In such a case, the feet could be loose or not well adjusted, and if it has nothing to do with the feet, it could be an unsteady or uneven surface.
Another possible explanation is an obstructed, worn-out, or broken blower. And if it has nothing to do with the blower, it’s highly likely a worn-out part such as the idler pulley, drum roller, or roller axle.
3. How Do You Fix a Rumbling Dryer?
You can only fix a rumbling dryer if you first recognize the cause of the annoying noise. Overall, here are some key steps you can use to do it:
- Ensure the dryer is steady and solid – It should be resting on a more solid and even surface, with all the feet touching the surface
- Clear any lint obstruction from the blower and replace the blower if it’s faulty
- Replace worn-out drum rollers or roller axles
- Also, replace a worn-out or damaged idler pulley
- Avoid overloading the dryer as it overworks the drum and its supportive components and may cause a rumbling noise.
Concluding Thought:
Discussed are the most likely explanations for a Samsung dryer making loud rumbling noise. In that case, start by checking for the possibility of the dryer being out of balance, the blower wheel being defective, or the idler pulley being worn out. And if that’s not the case, check for a loosely-spinning drum, which you can tell from worn-out support rollers or roller axles.
Also Read: